Effect of Furnace Slag Fiber on Strength and Deformation Characteristics of Cemental Sand

Gong Dahui; Chen Yang; Zhang Yan

doi:10.3969/j.issn.1000-6532.2023.03.014

2023 No. 3

Article Contents

Article navigation > Multipurpose Utilization of Mineral Resources > 2023 > 44(3): 82-87

Next Article Previous Article

Gong Dahui, Chen Yang, Zhang Yan. Effect of Furnace Slag Fiber on Strength and Deformation Characteristics of Cemental Sand[J]. Multipurpose Utilization of Mineral Resources, 2023, 44(3): 82-87. doi: 10.3969/j.issn.1000-6532.2023.03.014

Citation:

Gong Dahui, Chen Yang, Zhang Yan. Effect of Furnace Slag Fiber on Strength and Deformation Characteristics of Cemental Sand[J]. Multipurpose Utilization of Mineral Resources, 2023, 44(3): 82-87. doi: 10.3969/j.issn.1000-6532.2023.03.014

Effect of Furnace Slag Fiber on Strength and Deformation Characteristics of Cemental Sand

1.
China Railway 18th Bureau Group Co. Ltd , Tianjin , China
2.
School of Resources and Civil Engineering, Northeastern University, Shenyang, Liaoning, China

Received Date: 22 September 2021

Publish Date: 25 June 2023

Abstract

Abstract

This is a paper in the field of mineral ceramic materials. In order to enhance the mechanical properties of cemental sand materials and improve the utilization rate of mineral resources, the reinforced samples were made by mixing blast furnace slag fiber with river sand, cement and water. The effects of the content and length of furnace slag fibers on the strength characteristics of reinforced specimens were studied by unconfined compression tests. The results show that the unconfined strength of cemental sand samples increases with the increase of the content of furnace slag fiber, but the increase rate decreases obviously when the content of fiber reaches 0.3%. Using 5 mm and 10 mm fiber length to modify the cemented sand, the strengthening effect of the long fiber on the strength of the cemented sand is 1.25~1.55 times that of the short fiber under the condition of the same dosage. Through the microscopic morphology observation, it is found that the addition of furnace slag fibers to the cemental sand can improve the degree of adhesion between particles and agglomeration effect, and then enhance the strength and toughness of the cemented sand.
- Slag fiber /
- Ceramics and composite /
- Cemental sand /
- Unconfined compression experiment /
- Strength /
- Microstructure

FullText(HTML)

References

[1]	高洋. 高钛高炉渣综合利用现状及展望[J]. 矿产综合利用, 2019(1):6-10. GAO Y. Present situation and prospect of comprehensive utilization of high titanium blast furnace slag[J]. Multipurpose Utilization of Mineral Resources, 2019(1):6-10. doi: 10.3969/j.issn.1000-6532.2019.01.002 CrossRef Google Scholar GAO Y. Present situation and prospect of comprehensive utilization of high titanium blast furnace slag[J]. Multipurpose Utilization of Mineral Resources, 2019(1): 6-10. doi: 10.3969/j.issn.1000-6532.2019.01.002 CrossRef Google Scholar
[2]	严照照, 张淑会, 董晓旭, 等. 高炉渣的化学成分对其微观结构影响的研究现状[J]. 矿产综合利用, 2019(1):22-27. YAN Z Z, ZHANG S H, DONG X X, et al. Research status of the influence of blast furnace slag chemical composition on its microstructure[J]. Multipurpose Utilization of Mineral Resources, 2019(1):22-27. doi: 10.3969/j.issn.1000-6532.2019.01.005 CrossRef Google Scholar YAN Z Z, ZHANG S H, DONG X X, et al. Research status of the influence of blast furnace slag chemical composition on its microstructure[J]. Multipurpose Utilization of Mineral Resources, 2019(1): 22-27. doi: 10.3969/j.issn.1000-6532.2019.01.005 CrossRef Google Scholar
[3]	易耀林, 卿学文, 庄焱, 等. 粒化高炉矿渣微粉在软土固化中的应用及其加固机理[J]. 岩土工程学报, 2013, 35(S2):829-833. YI Y L, QING X W, ZHUANG Y, et al. Application of granulated blast furnace slag powder in soft soil solidification and its reinforcement mechanism[J]. Chinese Journal of Geotechnical Engineering, 2013, 35(S2):829-833. Google Scholar YI Y L, QING X W, ZHUANG Y, et al. Application of granulated blast furnace slag powder in soft soil solidification and its reinforcement mechanism[J]. Chinese Journal of Geotechnical Engineering, 2013, 35(S2): 829-833. Google Scholar
[4]	孙晓刚, 赵英良, 邢军, 等. 碱激发高炉矿渣-粉煤灰制备充填胶凝材料[J]. 金属矿山, 2016(11):189-192. SUN X G, ZHAO Y L, XING J, et al. Alkali-activated blast furnace slag-fly ash to prepare filling cementitious materials[J]. Metal Mine, 2016(11):189-192. doi: 10.3969/j.issn.1001-1250.2016.11.040 CrossRef Google Scholar SUN X G, ZHAO Y L, XING J, et al. Alkali-activated blast furnace slag-fly ash to prepare filling cementitious materials[J]. Metal Mine, 2016(11): 189-192. doi: 10.3969/j.issn.1001-1250.2016.11.040 CrossRef Google Scholar
[5]	张遵乾, 邢宏伟, 张玉柱. 熔渣离心成纤及纤维拉伸变形研究[J]. 矿产综合利用, 2018(5):138-142+146. ZHANG Z Q, XING H W, ZHANG Y Z. Study on the centrifugal fiber formation of molten slag and fiber tensile deformation[J]. Multipurpose Utilization of Mineral Resources, 2018(5):138-142+146. doi: 10.3969/j.issn.1000-6532.2018.05.031 CrossRef Google Scholar ZHANG Z Q, XING H W, ZHANG Y Z. Study on the centrifugal fiber formation of molten slag and fiber tensile deformation[J]. Multipurpose Utilization of Mineral Resources, 2018(5): 138-142+146. doi: 10.3969/j.issn.1000-6532.2018.05.031 CrossRef Google Scholar
[6]	唐续龙, 邢修君. 高炉渣和粉煤灰制备矿渣纤维实验研究[J]. 环境工程, 2020, 38(11):180-186. TANG X L, XING X J. Experimental research on preparation of slag fiber from blast furnace slag and fly ash[J]. Environmental Engineering, 2020, 38(11):180-186. Google Scholar TANG X L, XING X J. Experimental Research on Preparation of Slag Fiber from Blast Furnace Slag and Fly Ash[J]. Environmental Engineering, 2020, 38(11): 180-186. Google Scholar
[7]	范剑明, 李娜, 冯鑫国. 粉煤灰/矿渣复合基沙土固化剂的制备及固化性能研究[J]. 矿产综合利用, 2019(6):105-109. FAN J M, LI N, FENG X G. Study on preparation and curing performance of fly ash/slag-based soil stabilizer[J]. Multipurpose Utilization of Mineral Resources, 2019(6):105-109. doi: 10.3969/j.issn.1000-6532.2019.06.023 CrossRef Google Scholar FAN J M, LI N, FENG X G. Study on preparation and curing performance of fly ash/slag-based soil stabilizer[J]. Multipurpose Utilization of Mineral Resources, 2019(6): 105-109. doi: 10.3969/j.issn.1000-6532.2019.06.023 CrossRef Google Scholar
[8]	Erhan G, Yahya R. Atewi, Mustafa F. Hasan. Fresh and rheological properties of glass fiber reinforced self-compacting concrete with nanosilica and fly ash blended[J]. Construction and Building Materials, 2019, 211:349-362. Google Scholar
[9]	宁波, 闫艳, 左夏伟, 等. 铁尾矿砂混凝土力学特性实验研究[J]. 矿产综合利用, 2021(4):159-164. NING B, YAN Y, ZUO X W, et al. Experimental study on mechanical properties of iron tailings concrete[J]. Multipurpose Utilization of Mineral Resources, 2021(4):159-164. Google Scholar NING B, YAN Y, ZUO X W, et al. Experimental study on mechanical properties of iron tailings concrete [J]. Multipurpose Utilization of Mineral Resources, 2021(4): 159-164. Google Scholar
[10]	梁仕华, 曾伟华, 肖雪莉, 等. 纤维长度对微生物胶结砂力学性能的影响[J]. 工业建筑, 2019, 49(10):136-140. LIANG S H, ZENG W H, XIAO X L, et al. The effect of fiber length on the mechanical properties of microbial cemented sand[J]. Industrial Construction, 2019, 49(10):136-140. Google Scholar LIANG S H, ZENG W H , XIAO X L, et al. The effect of fiber length on the mechanical properties of microbial cemented sand[J]. Industrial Construction, 2019, 49(10): 136-140. Google Scholar
[11]	李博, 陈宇龙. 颗粒破碎条件下的胶结砂力学行为[J]. 西南交通大学学报, 2016, 51(4):729-735. LI B, CHEN Y L. Mechanical behavior of cemented sand under the condition of particle crushing[J]. Journal of Southwest Jiaotong University, 2016, 51(4):729-735. doi: 10.3969/j.issn.0258-2724.2016.04.018 CrossRef Google Scholar LI B, CHEN Y L. Mechanical behavior of cemented sand under the condition of particle crushing[J]. Journal of Southwest Jiaotong University, 2016, 51(4): 729-735. doi: 10.3969/j.issn.0258-2724.2016.04.018 CrossRef Google Scholar
[12]	Hadi Abioghli, Amir Hamidi. A constitutive model for evaluation of mechanical behavior of fiber-reinforced cemented sand[J]. Journal of Rock Mechanics and Geotechnical Engineering, 2019, 11(2):200-209. Google Scholar
[13]	姜屏, 杨建冬, 李娜, 等. 纤维改性水泥稳定铁尾矿砂的无侧限抗压性能研究[J]. 复合材料科学与工程, 2021(8):73-79. JIANG P, YANG J D, LI N, et al. Study on unconfined compressive performance of fiber-modified cement stabilized iron tailings[J]. Composite Materials Science and Engineering, 2021(8):73-79. Google Scholar JIANG P, YANG J D, LI N, et al. Study on unconfined compressive performance of fiber-modified cement stabilized iron tailings[J]. Composite Materials Science and Engineering, 2021(8): 73-79. Google Scholar
[14]	张广泰, 耿天娇, 鲁海波, 等. 冻融循环下沙漠砂纤维混凝土损伤模型研究[J]. 硅酸盐通报, 2021, 40(7):2225-2231. ZHANG G T, GENG T J, LU H B, et al. Research on damage model of desert sand fiber concrete under freeze-thaw cycles[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(7):2225-2231. Google Scholar ZHANG G T, GENG T J, LU H B, et al. Research on damage model of desert sand fiber concrete under freeze-thaw cycles[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(7): 2225-2231. Google Scholar