Decarbonization of Coal Gasification Slag by Oil Agglomeration Based on High Internal Phase W/O Emulsion

PENG Yang; LIAO Yinfei; CHEN Luojian; LUO Guolan; AN Maoyan

doi:10.13779/j.cnki.issn1001-0076.2023.06.004

2023 Vol. 43, No. 6

Article Contents

Article navigation > Conservation and Utilization of Mineral Resources > 2023 > 43(6): 33-40

Next Article Previous Article

PENG Yang, LIAO Yinfei, CHEN Luojian, LUO Guolan, AN Maoyan. Decarbonization of Coal Gasification Slag by Oil Agglomeration Based on High Internal Phase W/O Emulsion[J]. Conservation and Utilization of Mineral Resources, 2023, 43(6): 33-40. doi: 10.13779/j.cnki.issn1001-0076.2023.06.004

Citation:

PENG Yang, LIAO Yinfei, CHEN Luojian, LUO Guolan, AN Maoyan. Decarbonization of Coal Gasification Slag by Oil Agglomeration Based on High Internal Phase W/O Emulsion[J]. Conservation and Utilization of Mineral Resources, 2023, 43(6): 33-40. doi: 10.13779/j.cnki.issn1001-0076.2023.06.004

Decarbonization of Coal Gasification Slag by Oil Agglomeration Based on High Internal Phase W/O Emulsion

1.
School of Chemical Engineering & Technology, China University of Mining and Technology, Xuzhou 221116, Jiangsu China
2.
National Engineering Research Center of Coal Preparation and Purification, China University of Mining and Technology, Xuzhou 221116, Jiangsu China
3.
School of Transportation Engineering, Jiangsu Vocational Institute of Architectural Technology, Xuzhou 221116, Jiangsu China

More Information

Corresponding author: LIAO Yinfei, liaoyinfei@cumt.edu.cn

Received Date: 31 October 2023

Publish Date: 25 December 2023

Abstract

Abstract

The high carbon content of coal gasification residue and the mutual restriction of carbon ash hinder the resource utilization of coal gasification residue. Therefore, decarbonization is the basis of resource utilization and high value utilization of coal gasification slag. Due to the developed pores on the surface of coal gasification slag, the main decarburization methods, such as flotation and oil agglomeration, have the problems of high drug consumption and low carbon recovery rate. The high internal phase W/O emulsion is an oil−in−water emulsion with the volume of the internal water phase greater than 74.05%. The internal water phase replaces the oil to fill the pores on the surface of the coal gasification slag, which greatly reduces the fuel consumption. The properties of coal gasification slag samples were investigated by industrial analysis, X−ray diffraction (XRD) and scanning electron microscopy (SEM). The effects of surfactants, internal water ratio and inorganic salts on the stability and particle size of high internal W/O emulsions were studied by laser particle size analyzer and optical microscope. Finally, the decarbonization effect of high internal phase W/O emulsion with kerosene, diesel and SPAN80−oil mixture on coal gasification residue agglomeration was compared with the oil saving rate and carbon residue recovery rate. The results show that the fixed carbon content of the sample is 51.94%, and the main gangue minerals are quartz, calcite and anhydrite. The addition of alkali lignin, surfactant, NaCl and MgCl₂ can improve the stability of the emulsion. Compared with kerosene, diesel oil and SPAN80−oil mixture, the recovery rate of residual carbon in high internal phase W/O emulsion oil was increased by 14% on average, and the fuel saving rate was over 85%. Among them, the high internal phase W/O emulsion with 85% internal water, 25% surfactant and NaCl added has the best decarburization effect, and the recovery rate of carbon residue can reach 91.23%. The results show that high internal phase W/O emulsion oil agglomeration is an effective method to decarbonize coal gasification slag.
- coal gasification slag /
- oil agglomeration /
- high internal phase W/O emulsion /
- decarbonization

FullText(HTML)

References

[1]	朱菊芬, 李健, 闫龙, 等. 煤气化渣资源化利用研究进展及应用展望[J]. 洁净煤技术, 2019, 27(6): 11−21. Google Scholar ZHU J F, LI J, YAN L, et al. Research progress and application prospect of resource utilization of coal gasification slag[J]. Clean Coal Technology, 2019, 27(6): 11−21. Google Scholar
[2]	胡文豪. 煤气化渣铝硅组分活化分离与资源化利用基础研究[D]. 北京: 中国科学院大学(中国科学院过程工程研究所), 2019. Google Scholar HU W H. Basic research on activated separation and resource utilization of aluminum−silicon components from coal gasification slag[D]. Beijing: University of Chinese Academy of Sciences (Institute of Process Engineering, CAS), 2019. Google Scholar
[3]	仇韩峰. 煤气化灰渣资源环境属性研究[D]. 太原: 山西大学, 2021. Google Scholar QIU H F. Research on resource and environmental properties of coal gasification ash[D]. Taiyuan: Shanxi University, 2021. Google Scholar
[4]	胡志伟. 粉煤灰/气化炉渣未燃炭表面疏水性改善研究[D]. 徐州: 中国矿业大学, 2020. Google Scholar HU Z W. Study on improvement of surface hydrophobicity of fly ash/gasification slag unburned carbon[D]. Xuzhou: China University of Mining and Technology, 2020. Google Scholar
[5]	范宁, 张逸群, 樊盼盼, 等. 煤气化渣特性分析及资源化利用研究进展[J]. 洁净煤技术, 2022, 28(8): 145−154. Google Scholar FAN N, ZHANG Y Q, FAN P P, et al. Research progress on characteristics analysis and resource utilization of coal gasification slag[J]. Clean Coal Technology, 2022, 28(8): 145−154. Google Scholar
[6]	曲江山, 张建波, 孙志刚, 等. 煤气化渣综合利用研究进展[J]. 洁净煤技术, 2019, 26(1): 184−193. Google Scholar QU J S, ZHANG J B, SUN Z G, et al. Research progress of comprehensive utilization of coal gasification slag[J]. Clean Coal Technology, 2019, 26(1): 184−193. Google Scholar
[7]	任振玚, 井云环, 樊盼盼, 等. 气化渣水介重选及其分离炭制备脱硫脱硝活性焦实验研究[J]. 煤炭学报, 2021, 46(4): 1164−1172. Google Scholar REN Z Y, JING Y H, FAN P P, et al. Experimental study on water medium gravity separation of gasification slag and its separation of carbon to produce desulfurization and denitrification active coke[J]. Journal of China Coal Society, 2021, 46(4): 1164−1172. Google Scholar
[8]	于伟, 王学斌, 白永辉, 等. 煤气化细渣浮选脱碳实验研究[J]. 洁净煤技术, 2019, 27(3): 81−87. Google Scholar YU W, WANG X B, BAI Y H, et al. Experimental study on flotation decarburization of fine slag from coal gasification[J]. Clean Coal Technology, 2019, 27(3): 81−87. Google Scholar
[9]	胡俊阳. 北方某煤气化炉渣的综合利用研究[D]. 绵阳: 西南科技大学, 2018. Google Scholar HU J Y. Research on comprehensive utilization of a coal gasification furnace slag in North China[D]. Mianyang: Southwest University of Science and Technology, 2018. Google Scholar
[10]	张晓峰, 王玉飞, 范晓勇, 等. 煤气化细渣浮选脱碳分析[J]. 能源化工, 2016, 37(5): 54−57. Google Scholar ZHANG X F, WANG Y F, FAN X Y, et al. Analysis of decarburization by flotation of fine slag from coal gasification J]. Energy & Chemical Industry, 2016, 37(5): 54−57. Google Scholar
[11]	吴思萍, 赵凯, 董永胜, 等. 气化细渣浮选脱碳研究进展[J]. 华电技术, 2019, 42(7): 81−86. Google Scholar WU S P, ZHAO K, DONG Y S, et al. Research progress of decarburization by flotation of gasification fine slag[J]. Huadian Technology, 2019, 42(7): 81−86. Google Scholar
[12]	宇文超, 王春耀, 朱述川, 等. 微细粒煤分选技术研究进展[J]. 煤炭加工与综合利用, 2021(8): 4−9. Google Scholar YU W C, WANG C Y, ZHU S C, et al. Research progress of micro−fine coal separation technology[J]. Coal Processing and Comprehensive Utilization, 2021(8): 4−9. Google Scholar
[13]	薛中华. 煤气化细渣疏水−亲水双液炭/灰分离研究[D]. 太原: 太原理工大学, 2022. Google Scholar XUE Z H. Study on hydrophobic and hydrophilic dual−liquid carbon/ash separation of fine slag from coal gasification[D]. Taiyuan: Taiyuan University of Technology, 2022. Google Scholar
[14]	宋元瑞. 以高内相乳液为模板制备多孔聚合物材料用于染料废水处理[D]. 合肥: 中国科学技术大学, 2020. Google Scholar SONG Y R. Preparation of porous polymer materials for dye wastewater treatment using high internal phase emulsion as template[D]. Hefei: University of Science and Technology of China, 2020. Google Scholar
[15]	NETTEN K V , MORENO−ATANASIO R , GALVIN K P , et al. A kinetic study of a modified fine coal agglomeration process[C]//World Congress on Particle Technology. 2015. Google Scholar
[16]	ZHAO X , TANG Y , ZHAO B. Collecting behaviors of high internal phase (HIP) emulsion in flotation of ultrafine high−ash content coal slime[J]. International Journal of Coal Preparation and Utilization, 2021(11): 1−21. Google Scholar
[17]	LU Y , WANG X , LIU W , Dispersion behavior and attachment of high internal phase water−in−oil emulsion droplets during fine coal flotation[J]. Fuel, 2019, 253: 273−282. Google Scholar
[18]	李可扬, 张卓, 董姝丽. 高内相乳液的制备、性能及其在功能材料制备上的应用[J]. 科学通报, 2021, 66(14): 1703−1716. Google Scholar LI K Y, ZHANG Z, DONG S L. Preparation, properties and application of high internal phase emulsions in the preparation of functional materials[J]. Chinese Science Bulletin, 201, 66(14): 1703−1716. Google Scholar
[19]	卫姣, 陈雨露, 高彦祥, 等. 高内相乳液的制备及在食品中的应用[J]. 中国食品学报, 2022, 22(4): 418−429. Google Scholar WEI J, CHEN Y L, GAO Y X, et al. Preparation of high internal phase emulsion and its application in food[J]. Chinese Journal of Food Science, 2022, 22(4): 418−429. Google Scholar