Experiment on Production of Silicon Fertilizer from Polyaluminum Chloride Industrial Waste Residue

Gao Hongli; Zhao Fenglan; Wang Yuhan; Hu Junzhou; Guo Lei; Li Hongtao

doi:10.3969/j.issn.1000-6532.2022.05.003

2022 No. 5

Article Contents

Article navigation > Multipurpose Utilization of Mineral Resources > 2022 > 43(5): 15-19

Next Article Previous Article

Gao Hongli, Zhao Fenglan, Wang Yuhan, Hu Junzhou, Guo Lei, Li Hongtao. Experiment on Production of Silicon Fertilizer from Polyaluminum Chloride Industrial Waste Residue[J]. Multipurpose Utilization of Mineral Resources, 2022, 43(5): 15-19. doi: 10.3969/j.issn.1000-6532.2022.05.003

Citation:

Gao Hongli, Zhao Fenglan, Wang Yuhan, Hu Junzhou, Guo Lei, Li Hongtao. Experiment on Production of Silicon Fertilizer from Polyaluminum Chloride Industrial Waste Residue[J]. Multipurpose Utilization of Mineral Resources, 2022, 43(5): 15-19. doi: 10.3969/j.issn.1000-6532.2022.05.003

Experiment on Production of Silicon Fertilizer from Polyaluminum Chloride Industrial Waste Residue

Institute of geography, Henan Provincial Academy of Sciences, Zhengzhou, Henan, China

Received Date: 18 July 2021

Publish Date: 25 October 2022

Abstract

Abstract

Using polyaluminum chloride residue as raw material, the effects of roasting temperature, roasting time, additive ratio and other factors on the activation effect of silicon dioxide in polyaluminum chloride residue were studied by single factor experiment and orthogonal design, and the technological conditions for producing silicon fertilizer from polyaluminum chloride residue were determined. The results show that the significant influence of three factors effective silicon content and the activation rate of silicon in polyaluminum chloride waste residue is as follows: activator dosage > calcination temperature > calcination time. The amount of activator and calcination temperature have obvious influence on the content of effective silicon in the calcined product, while the calcination time has no obvious influence on the content of effective silicon in the calcined product. With the increase of the amount of activator, the effective silicon content in the product increases. When the amount of activator reaches 41%, the effective silicon content tends to be stable, and the correlation coefficient between the amount of activator and the effective silicon content reaches 0.9829; with the increase of calcination temperature, the effective silicon content in the product increases, and reaches the peak after 1250℃, when the temperature is 1240～1270℃, the time is 30～40 min and the dosage of activator is 41%～45%, the content of effective silicon in the product is the highest, reaching about 30%.
- Waste residue of polyaluminum chloride /
- Orthogonal test /
- Silicon fertilizer /
- Effective silicon content

FullText(HTML)

References

[1]	李柏林, 梁亚楠, 张程琛, 等. 粉煤灰-铝土矿改性制备铝铁复合混凝剂的除磷性能及混凝机理研究[J]. 环境科学学报, 2016, 36( 7): 2503-2511. Google Scholar LI B L, LIANG Y N, ZHANG C C, et al. Preparation of monohydrallite-coal ash composite flocculant: phosphorus removal performance and flocculation mechanism[J]. Acta Scientiae Circumstantiae, 36(7): 2503-2511. Google Scholar
[2]	杨茹霞, 孙慧芳, 张国栋, 等. 聚合氯化铝靶向混凝去除焦化废水难降解有机物的研究[J]. 工业用水与废水, 2017, 48(6):16-21. doi: 10.3969/j.issn.1009-2455.2017.06.004 CrossRef Google Scholar YANG R X, SUN H F, ZHANG G D, et al. Removal of hard-degradable organic matters from coking wastewater by polyaluminum chloride targeted coagulation[J]. Industrial Water & Wastewater, 2017, 48(6):16-21. doi: 10.3969/j.issn.1009-2455.2017.06.004 CrossRef Google Scholar
[3]	李沛伦, 胡真, 王成行, 等. 酸改性粉煤灰的制备及其降解选矿废水COD研究[J]. 矿产综合利用, 2019(2):103-108. doi: 10.3969/j.issn.1000-6532.2019.02.021 CrossRef Google Scholar LI P L, HU Z, WANG C X, et al. Experimental study on preparation of acid modified fly ash and its degradation of COD in mineral processing wastewater[J]. Multipurpose Utilization of Mineral Resources, 2019(2):103-108. doi: 10.3969/j.issn.1000-6532.2019.02.021 CrossRef Google Scholar
[4]	刘三军, 刘永, 李向阳, 等. 用铝土矿选矿尾矿制备聚合氯化铝及污水处理实验研究[J]. 湿法冶金, 2020, 39(6):539-542. Google Scholar LIU S J, LIU Y, LI X Y, et al. Preparation of polyaluminum chloride using bauxite tailings and its application in wastewater treatment[J]. Hydrometallurgy of China, 2020, 39(6):539-542. Google Scholar
[5]	李凡修, 陈武. 聚合氯化铝制备技术的研究现状和进展[J]. 工业水处理, 2003, 23(3):5-8. doi: 10.3969/j.issn.1005-829X.2003.03.002 CrossRef Google Scholar LI F X, CHEN W. Recent development in preparation of polyaluminium chloride[J]. Industrial Water Treatment, 2003, 23(3):5-8. doi: 10.3969/j.issn.1005-829X.2003.03.002 CrossRef Google Scholar
[6]	闫玉兵. 改性粉煤灰对含磷废水的处理研究进展[J]. 矿产综合利用, 2020(5):34-44. doi: 10.3969/j.issn.1000-6532.2020.05.004 CrossRef Google Scholar YAN Y B. Research on modified fly ash treats for phosphorus wastewater[J]. Multipurpose Utilization of Mineral Resources, 2020(5):34-44. doi: 10.3969/j.issn.1000-6532.2020.05.004 CrossRef Google Scholar
[7]	郭庆, 陈书文, 张军红, 等. 微波强化赤泥制备Fe-Al基絮凝剂工艺研究[J]. 矿产综合利用, 2019(4):117-121. doi: 10.3969/j.issn.1000-6532.2019.04.025 CrossRef Google Scholar GUO Q, CHEN S W, ZHANG J H, et al. Study on preparation of Fe/Al-base flocculant from red mud by microwave[J]. Multipurpose Utilization of Mineral Resources, 2019(4):117-121. doi: 10.3969/j.issn.1000-6532.2019.04.025 CrossRef Google Scholar
[8]	李晴淘, 张淳之, 周吉峙, 等. 改性聚铝废渣对污泥脱水性能的影响[J]. 工业水处理, 2019, 39(12):79-81. doi: 10.11894/iwt.2018-0999 CrossRef Google Scholar LI Q T, ZHANG C Z, ZHOU J Z, et al. Improvement of sludge dewatering capability with modified polyaluminium chloride residue[J]. Industrial Water Treatment, 2019, 39(12):79-81. doi: 10.11894/iwt.2018-0999 CrossRef Google Scholar
[9]	高红莉, 李洪涛, 张硌, 等. 不同前处理方法对粉煤灰有效成分提取率的影响[J]. 煤炭科学技术, 2016, 44(S1):205-209. Google Scholar GAO H L, LI H T, ZHANG L, et al. Effect of different pretreatment methods on extraction rate of effective components of fly ash[J]. Coal Science and Technology, 2016, 44(S1):205-209. Google Scholar
[10]	高红莉, 李洪涛, 郭雷, 等. 粉煤灰聚硅酸铝铁絮凝剂对含磷废水处理效果的研究[J]. 河南科学, 2017, 35(6):985-989. doi: 10.3969/j.issn.1004-3918.2017.06.025 CrossRef Google Scholar GAO H L, LI H T, GUO L, et al. Treatment effect of fly ash based polysilicate-aluminum-ferric flocculant on phosphorus wastewater[J]. Henan Science, 2017, 35(6):985-989. doi: 10.3969/j.issn.1004-3918.2017.06.025 CrossRef Google Scholar