Experimental study on salt-water cement slurry for plugging in geological drilling

YANG Kuancai and KONG Erwei; ${author.authorNameEn}

doi:10.12143/j.ztgc.2023.05.014

2023 Vol. 50, No. 5

Article Contents

Article navigation > DRILLING ENGINEERING > 2023 > 50(5): 95-100

Next Article Previous Article

YANG Kuancai and KONG Erwei, . 2023. Experimental study on salt-water cement slurry for plugging in geological drilling. DRILLING ENGINEERING, 50(5): 95-100. doi: 10.12143/j.ztgc.2023.05.014

Citation:

YANG Kuancai and KONG Erwei, . 2023. Experimental study on salt-water cement slurry for plugging in geological drilling. DRILLING ENGINEERING, 50(5): 95-100. doi: 10.12143/j.ztgc.2023.05.014

Experimental study on salt-water cement slurry for plugging in geological drilling

1.The Fourth Geological Exploration Institute Co. Ltd of Henan Province, Zhengzhou Henan 450001, China;
2.Research Center of Slim-hole Drilling Engineering Technology in Henan Province, Zhengzhou Henan 450001, China

Received Date: 07 June 2023

Revised Date: 10 July 2023

Abstract

Abstract

In Qinghai， Xinjiang and other arid areas of China， some mining site water is brine with high salt content. For convenience， salt water is used to prepare cement plugging slurry. A set of salt-water cement plugging slurry system for geological drilling is developed through the selection of various cement admixtures， and the conventional and plugging properties have been comprehensively evaluated. The results showed good fluidity， filtration reducing property and sedimentary stability， the early compressive and flexural strength of the system is greater， and the final coagulation time is shorter. 5% sodium chloride shows obvious early strength and promoting coagulation for cement slurry. The thickening time of the system at 30MPa and 45~75℃ is 110~170min， the slurry is stable， and the thickening characteristics are good， which can effectively plug up the orifice and seam plate. The saltwater cement slurry system has a good application prospect in the plugging operation of fractured formation in similar areas.
- geological drilling /
- fractured formation /
- plugging /
- salt-water cement slurry /
- NaCl

FullText(HTML)

References

[1]	薛玉志，刘振东，唐代绪，等.裂缝性地层堵漏配方及规律性研究［J］.钻井液与完井液，2009，26（6）：28-30. Google Scholar XUE Yuzhi， LIU Zhendong， TANG Daixu， et al. Study on the formulation of lost circulation control fluid and the laws of lost circulation control for fractured formations［J］. Drilling Fluid & Completion Fluid， 2009，26（6）：28-30. Google Scholar
[2]	[2] 徐同台，刘玉杰，申威.钻井工程防漏堵漏技术［M］.北京：石油工业出版社，1997.XU Tongtai， LIU Yujie， SHEN Wei. Drilling Engineering Leak Prevention and Sealing Technology［M］. Beijing： Petroleum Industry Press， 1997. Google Scholar
[3]	[3] 张希文，李爽，张洁，等.钻井液堵漏材料及防漏堵漏技术研究进展［J］.钻井液与完井液，2009，26（6）：74-76. Google Scholar ZHANG Xiwen， LI Shuang， ZHANG Jie， et al. Research progress on lost circulation materials and lost circulation control technology［J］. Drilling Fluid & Completion Fluid， 2009，26（6）：74-76. Google Scholar
[4]	[4] 贾利春，陈勉，侯冰，等.裂缝性地层钻井液漏失模型及漏失规律［J］.石油勘探与开发，2014，41（1）：95-101. Google Scholar JIA Lichun， CHEN Mian， HOU Bing， et al. Drilling fluid loss model and loss dynamic behavior in fractured formations［J］. Petroleum Exploration and Development， 2014，41（1）：95-101. Google Scholar
[5]	[5] 吕斌，侯力伟，王克诚.新型承压堵漏水泥浆体系的室内研究［J］.钻井液与完井液，2011，28（4）：51-53. Google Scholar Bin LÜ， HOU Liwei， WANG Kecheng. Laboratory research of new sealing under pressure cement slurry system［J］. Drilling Fluid & Completion Fluid， 2011，28（4）：51-53. Google Scholar
[6]	[6] 李子硕，薛曼，李智，等.松软煤层加固用泡沫水泥浆的实验研究［J］.钻探工程，2023，50（3）：130-138. Google Scholar LI Zishuo， XUE Man， LI Zhi， et al. Experimental study of foamed cement slurry for soft coal seam reinforcement［J］. Drilling Engineering， 2023，50（3）：130-138. Google Scholar
[7]	[7] 刘学鹏.温敏堵漏水泥浆体系研究与应用［J］.钻探工程，2022，49（2）：110-116. Google Scholar LIU Xuepeng. Research and application of the temperature sensitive plugging cement slurry system［J］. Drilling Engineering， 2022，49（2）：110-116. Google Scholar
[8]	[8] 景龙，李兴权，鲍石磊，等.基于压力平衡条件下“戴帽”固井注水泥技术探讨［J］.钻探工程，2023，50（2）：79-84. Google Scholar JING Long， LI Xingquan， BAO Shilei， et al. Discussion of cement injection technology for “cap” cementation based on balanced pressure condition［J］. Drilling Engineering， 2023，50（2）：79-84. Google Scholar
[9]	[9] 张敬涛，王晓亮.Y油田盐膏层固井水泥浆及前置液性能评价［J］.化学工程师，2022，36（12）：58-62，41. Google Scholar ZHANG Jingtao， WANG Xiaoliang. Performance evaluation of cementing slurry and preflush for salt gypsum formation in Y Oilfield［J］. Chemical Engineer， 2022，36（12）：58-62，41. Google Scholar
[10]	[10] Cunningham Willis C， Smith Dwight K. Effect of salt cement filtrate on subsurface formations［J］. Journal of Petroleum Technology， 1968，20（3）：259-264. Google Scholar
[11]	[11] Slagle Knox A， Smith Dwight K. Salt cement for shale and bentonitic sands［J］. Journal of Petroleum Technology， 1963，15（2）：187-194. Google Scholar
[12]	[12] Goodwin Korwin. J.， Keith Phipps. Salt free cement-An alternative to collapsed casing in plastic salts［J］. Journal of Petroleum Technology， 1983，36（2）：320-324. Google Scholar
[13]	[13] Ismail S. A. A.， Khalaf Fouad. Effectiveness of low-salt cement opposite salt bodies［C］//Middle East Oil Show. SPE-25542-MS， 1993. Google Scholar
[14]	[14] 张弛，刘硕琼，徐明，等.低温胶乳盐水水泥浆体系研究与应用［J］.钻井液与完井液，2013，30（2）：63-65. Google Scholar ZHANG Chi， LIU Shuoqiong， XU Ming， et al. Research on low temperature latex brine cement slurry system［J］. Drilling Fluid & Completion Fluid， 2013，30（2）：63-65. Google Scholar
[15]	[15] 罗刚，舒福昌，向兴金.高温盐水水泥浆体系的室内研究［J］.海洋石油，2009，29（2）：92-96. Google Scholar LUO Gang， SHU Fuchang， XIANG Xingjin. Laboratory study of high-temperature saltwater cement slurry［J］. Offshore Oil， 2009，29（2）：92-96. Google Scholar
[16]	[16] 丹美涵.抗盐高性能水泥浆体系研究与应用［J］.钻井液与完井液，2021，38（2）：249-254. Google Scholar DAN Meihan. Study and application of a high-performance salt-resistant cement slurry［J］. Drilling Fluid & Completion Fluid， 2021，38（2）：249-254. Google Scholar
[17]	[17] 陈良，彭博，黄敏.聚合物氯化钾水泥浆体系性能评价及应用研究［J］.长江大学学报（自然科学版），2015， 12（25）：14-16. Google Scholar CHEN Liang， PENG Bo， HUANG Min. Performance evaluation and application of polymer potassium chloride cement slurry system in well GK-1［J］. Journal of Yangtze University （Natural Science Edition）， 2015，12（25）：14-16. Google Scholar
[18]	[18] Niu X， Feng G， Han Y， et al. Synergistic effect of surfactant and chlorine salt on dispersion of nano-SiO₂ and performance of cement-based grout containing a large amount of bentonite［J］. Cement and Concrete Composites， 2022，131：104587. Google Scholar
[19]	[19] Gilson Campos， Simao Cristina Alex， Miranda Cristiane Richard de， et al. Salt tolerant cement systems to mitigate gelling effect［C］//IADC/SPE Asia Pacific Drilling Technology Conference. SPE-170477-MS， 2014. Google Scholar
[20]	[20] Al Moajil Abdullah M.， Nasr-El-Din Hisham A.， Kar Yusuf， et al. Dispersants for cement and salt contaminated manganese tetraoxide high-density water-based drilling fluids［C］//Abu Dhabi International Petroleum Exhibition and Conference. SPE-177935-MS， 2015. Google Scholar
[21]	[21] Kang C， Kim T. Influence of brine on hydration reaction of calcium sulfoaluminate and slag blended cement［J］. Case Studies in Construction Materials， 2023，18：e02159. Google Scholar
[22]	[22] Reddy B. R.， Contreras Elizabeth Q.， Boul Peter J. Relating cement additive performance to mix water composition for deep water and salt zone applications［C］//Deepwater Drilling and Completions Conference. SPE-180344-MS， 2016. Google Scholar
[23]	[23] 腾新荣.表面物理化学［M］.北京：化学工业出版社，2009.TENG Xinrong. Surface Physical Chemistry［M］. Beijing： Chemical Industry Press， 2009. Google Scholar
[24]	[24] 王复生，朱元娜，孙胜泉.氯化钠对普通硅酸盐水泥的早强作用和结合方式的试验研究［C］//“全国特种混凝土技术及工程应用”学术交流会暨2008年混凝土质量专业委员会年会论文集.西安：2008：184-189. Google Scholar WANG Fusheng， ZHU Yuanna， SUN Shengquan. Experimental study on the early strength effect and bonding mode of sodium chloride on ordinary Portland cement［C］//Proceedings of the Academic Exchange Conference on “National Special Concrete Technology and Engineering Applications” and the 2008 Annual Meeting of the Concrete Quality Professional Committee. Xi’an： 2008：184-189. Google Scholar
[25]	[25] 杨现禹，岳也，蔡记华.化学发泡式泡沫水泥浆稠化实验方法对比与分析［J］.钻井液与完井液，2016，33（2）：96-100. Google Scholar YANG Xianyu， YUE Ye， CAI Jjihua. Comparison and analysis of thickening experiment methods for chemically foamed cement slurry［J］. Drilling Fluid & Completion Fluid， 2016，33（2）：96-100. Google Scholar
[26]	[26] 谷穗，乌效鸣，蔡记华.纤维水泥浆堵漏实验研究［J］.探矿工程（岩土钻掘工程），2009，36（4）：4-6. Google Scholar GU Sui， WU Xiaoming， CAI Jihua. Sealing experiment research on fiber cement slurry［J］. Exploration Engineering （Rock & Soil Drilling and Tunneling）， 2009，36（4）：4-6. Google Scholar